VENT-FREE GAS SYSTEMOWNER'S OPERATION AND INSTALLATION MANUALMODELSFBD400RTCC-M-HC/MOFBD400TCC-M-HC/MOPFS®US WARNING: If the information in this
www.usaprocom.com200020-01A10INSTALLATIONNOTICE: This heater is intended for use as supplemental heat. Use this heater along with your primary hea
www.usaprocom.com11200020-01ANGLPLeft Side of HeaterBack of HeaterNGLPGas InletGas estéNGLPBack Side of HeaterINSTALLATIONGAS SELECTIONThis appliance
www.usaprocom.com200020-01A12NGLPLeft Side of HeaterBack of HeaterNGLPGas InletGas estéINSTALLATIONCLEARANCES TO COMBUSTIBLES WARNING: You must main-t
www.usaprocom.com13200020-01AINSTALLATIONCONNECTING TO GAS SUPPLY CAUTION: For natural gas, check your gas line pressure before connecting heat
www.usaprocom.com200020-01A14INSTALLATIONFigure 8 - Gas Connection* Purchase the optional CSA design-certied equipment shutoff valve from your dealer
www.usaprocom.com15200020-01AINSTALLATIONFigure 10 - Equipment Shutoff ValveCHECKING GAS CONNECTIONSOpenClosedEquipment Shutoff ValvePRESSURE TESTING
www.usaprocom.com200020-01A16INSTALLATIONINSTALLING LOGS WARNING: Failure to posi-tion the parts in accordance with these diagrams or fail
www.usaprocom.com17200020-01AINSTALLATIONFigure 15 - Installing Log #4Figure 16 - Installing Log #5 and #6Pin for Log #5Log #5Hole for Log #6Log #6Log
www.usaprocom.com200020-01A18OPERATION WARNING: If you do not fol-low these instructions exactly, a re or explosion may result causing property
www.usaprocom.com19200020-01A7. With control knob pressed in, push down and release ignitor button. This will light pilot. The pilot is
www.usaprocom.com200020-01A2TABLE OF CONTENTSSafety ... 3Specications ...
www.usaprocom.com200020-01A20OPERATIONMODELS FBD400RTCC-M-HC/MOLIGHTING INSTRUCTIONS WARNING: You must oper-ate this heater with the screen in place
www.usaprocom.com21200020-01AOPERATION CAUTION: Do not try to ad-just heating levels by using the equipment shutoff valve. WARNING: If input gas t
www.usaprocom.com200020-01A22OPERATIONKey SettingsON - Operates unit to on position, manually operated solenoid ON.OFF - Operates unit to off position
www.usaprocom.com23200020-01AOPERATION1. Press the MODE key until the LCD screen shows the word ROOM. The remote is now in the thermostatic mod
www.usaprocom.com200020-01A24INSPECTING BURNERSIMPORTANT: Owner’s should check pilot ame pattern and burner ame pattern often. Incorrect ame patte
www.usaprocom.com25200020-01ABURNER INJECTOR HOLDER AND PILOT AIR INLET HOLEWe recommend that you clean the unit ev-ery 2,500 hours of operation or
www.usaprocom.com200020-01A26Use a vacuum cleaner, pressurized air, or a small, soft bristled brush to clean.A yellow tip on the pilot ame indicates
www.usaprocom.com27200020-01ATROUBLESHOOTING WARNING: If you smell gas:• Shut off gas supply.• Do not try to light any appliance.• Do not touch any
www.usaprocom.com200020-01A28Problem Possible Cause Corrective ActionODS/pilot lights but ame goes out when control knob is released.1. Control k
www.usaprocom.com29200020-01ATROUBLESHOOTINGProblem Possible Cause Corrective ActionSlight smoke or odor during initial operation.1. Residues from
www.usaprocom.com3200020-01A WARNING: Any change to this heater or its controls can be dangerous. WARNING: Do not use a blower insert, heat exc
www.usaprocom.com200020-01A30PARTSMODELS FBD400RTCC-M-HC/MOFBD400TCC-M-HC/MO98101211132218192014152161234167517PILOTOFFONREMOTEOFFONLEARNTEMP
www.usaprocom.com31200020-01APARTSMODELS FBD400RTCC-M-HC/MOFBD400TCC-M-HC/MOThis list contains replaceable parts used in your heater. When or
www.usaprocom.com200020-01A32REPLACEMENT PARTSNote: Use only original replacement parts. This will protect your warranty coverage for parts replaced u
www.usaprocom.com33200020-01ASERVICE HINTSWhen Gas Pressure Is Too Low• pilot will not stay lit• burners will have delayed ignition• replace will
www.usaprocom.com200020-01A34NOTES____________________________________________________________________________________________________________________
www.usaprocom.com35200020-01ANOTES____________________________________________________________________________________________________________________
200020-01Rev. A06/13REGISTER YOUR PRODUCT AT WWW.USAPROCOM.COMIMPORTANT: We urge you to register your product within 10 days of date of installation,
www.usaprocom.com200020-01A41. Do not place Propane/LP supply tank(s) inside any structure. Propane/LP supply tank(s) must be placed outdoors.2. Thi
www.usaprocom.com5200020-01ASPECIFICATIONSMODELS FBD400TCC-M-HC/MOGas Type Natural Propane/LPMaximum Input Rating 32,000 BTU/Hr 32,000 BTU/HrMinimum I
www.usaprocom.com200020-01A6Figure 1 - Vent-Free Fireplace InsertHoodScreenLogsHeater Controls (Inside Panel)Install and use heater with care. F
www.usaprocom.com7200020-01AWATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERSWater vapor is a by-product of gas combus-tion. An unvented room heater
www.usaprocom.com200020-01A8DETERMINING FRESH-AIR FLOW FOR HEATER LOCATIONDetermining if You Have a Conned or Unconned Space3. Add the Btu/Hr of al
www.usaprocom.com9200020-01AVENTILATION AIRAIR FOR COMBUSTION AND VENTILATIONOutlet Air Ventilated Attic OutletAirInletAirInlet Air Ventilated Crawl
Commentaires sur ces manuels